2010 supplement C30, Motoryzacja rozne

2010 supplement C30

2010 supplement C30, Motoryzacja rozne

[ Pobierz całość w formacie PDF ]
VOLVO C30, S40 (04-), V50 & C70 (06-)
WIRING DIAGRAM
S40, V50
2010 supplement
C30, C70
2011 Supplement
TP 39167202 LATE DESIGN
Vehicles with SRS (Airbag)/SIPS bag/IC
(Inflatable Curtain)
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.
2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.
Is the vehicle equipped with SRS/SIPS bag/IC?
Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering
wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the
dashboard above the glove compartment. SRS vehicles from 1993 and onward also have
explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and
onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with
IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).
General recommendations
• Be especially careful when working on or around SRS, SIPS, and IC components.
• Make sure that no wires are pinched, frayed, or pierced.
• Never install accessories by the sensors.
• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VIDA.
• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VIDA.
• Install no accessories in the areas between the A and B posts, the B and C posts, and the C
and D posts.
Test terminal
Data link connector in the passenger compartment.
Changes introduced up to and including June 2009
Any changes made to the vehicles after this date are not included in the manual. If necessary
refer to service bulletins.
Volvo models are sold in versions adapted for different markets. These adaptations depend
on factors such as legal requirements, taxation, and market demands.
This manual may therefore include illustrations and text that do not apply to the vehicles in
your country.
Ordering:
Electronic Wiring Diagrams (EWD) can be ordered from Technical Information Shop (TIS) at
www.volvocarstechinfo.ford.com/vss
We retain the right to make modifications
© Volvo Car Corporation
Table of Contents 1:2
Vehicles with SRS (Airbag)/SIPS bag/
IC (Inflatable Curtain)..................................................... 2
Abbreviations ................................................................. 5
How to use the wiring diagrams 1:2............................... 6
Electrical distribution 1:2................................................ 8
Group 36 Additional electrical equipment
Direction indicators and hazard warning flashers
C30/C70....................................................................... 54
Direction indicators and hazard warning flashers
(Dual Xenon) C30/C70................................................. 55
Keyless vehicle C30/S40/V50 1:2................................ 56
Immobilizer/Steering column lock module (SCL) ......... 58
Fuses
Distribution box in engine compartment F1-F7............. 10
Distribution box in engine compartment F8-F16........... 11
Distribution box in engine compartment F17-F25......... 12
Distribution box in engine compartment F26-F32......... 13
Distribution box in engine compartment F33-F34......... 14
Distribution box in engine compartment F35-FH1 ........ 15
Main fuse box battery ................................................... 16
Fuse holder midi ........................................................... 17
Central Electronic Module (CEM) F43-F48................... 18
Central Electronic Module (CEM) F49-F61................... 19
Central Electronic Module (CEM) F62-F69................... 20
Central Electronic Module (CEM) F73-F85................... 21
Central Electronic Module (CEM) F86 .......................... 22
Battery PF1-PF2 ........................................................... 23
Group 37 Wiring and fuses, Accessories
Cable harness towbar/tow hitch 4-pin C30/C70........... 59
Cable harness towbar/tow hitch 7-pin C30/C70........... 60
Cable harness towbar/tow hitch 13-pin S40/V50/C70 . 61
Group 38 Instruments
Seat belt reminder C30/S40/V50 ................................. 62
Seat belt reminder C70 ................................................ 63
Group 39 Other
Audio High Performance/Premium Sound
C30/S40/V50 1:2 ......................................................... 64
Alternative connection audio S40/V50 ......................... 66
Cellular phone 1:2........................................................ 67
Bluetooth...................................................................... 69
Bluetooth Handsfree, external amplifier....................... 70
Bluetooth Handsfree & AUU, external amplifier........... 71
Relays
Ignition switch and relays............................................. 24
Distribution box in engine compartment R1-R14 ......... 25
Engine compartment.................................................... 26
Central electronic module (CEM) R15-R18 ................. 27
Central electronic module (CEM) R1-R11B................. 28
Other relays ................................................................. 29
Group 59 Brake system
Brake control system & DSTC ..................................... 72
Control modules
Central electronic module (CEM) 1:2........................... 30
Data communication, Low speed CAN 1:2 .................. 32
Data communication, High speed CAN ....................... 34
Data communication MOST......................................... 35
Data communication LIN 1:2 ....................................... 36
Ignition switch (SCU) ................................................... 38
Accessory electronic module (AEM)............................ 39
Group 83 Doors and openings
Central locking front doors C30/S40/V50..................... 73
Child safety lock S40/V50 ............................................ 74
Power windows front doors C30/S40/V50 ................... 75
Power windows C70 .................................................... 76
Power windows rear doors S40/V50............................ 77
Group 23 Fuel system
Engine management system, 5-Cyl. 1:2...................... 40
Engine management system Diesel, 4-Cyl. 1.6l 1:2 .... 42
Group 33 Starting system
Starting system 4-Cyl................................................... 44
Group 35 Lighting
Active headlight, (Dual Xenon), C30/C70 .................... 45
Running/Parking lights, Tail lights C30/C70 ................ 46
Running/Parking lights, Tail lights (Dual Xenon)
C30/C70....................................................................... 47
Brake lights C30/C70................................................... 48
Reversing lights C30/C70 ............................................ 49
Fog lights C30/C70 ...................................................... 50
Fog lights LHD Japan C30/C70 ................................... 51
Interior lighting C30/S40/V50 1:2................................. 52
TP 39167202 C30/S40 (04-)/V50/C70 (06-) 2010 Supplement
3
Table of Contents 2:2
Group 84 Exterior decorative elements, etc.
Power door mirrors C30/S40/V50................................ 78
Power door mirrors C70............................................... 79
Connectors ................................................ 80
Branching points .....................................103
Cable harness routing in vehicle
Harness dashboard, LHD ........................................... 106
Harness Dashboard, RHD .......................................... 106
Component illustrations ..........................107
Index ..........................................................138
List of components 1:4 ............................139
TP 39167202 C30/S40 (04-)/V50/C70 (06-) 2010 Supplement
4
Explanations
Abbreviations
Groups
Group 23
Other
ACC
= Fuel system
= Accessories
Group 26
= Cooling system
Ag
= Silver plated
Group 27
= Engine controls
Au
= Gold plated
Group 32
= Alternator and voltage regulator
AUTO
= Automatic transmission
Group 33
= Starting system
AUTODIM
= Automatic dimming, rear-view mirror
Group 35
= Lighting
AWD
= All wheel drive
Group 36
= Additional electrical equipment
CAN
= CAN communication
Group 37
= Wiring and fuses
D
= Diesel
Group 38
= Instruments
DPY
= Display
Group 39
= Other
ECC
= Electronic climate control system
Group 43
= Transmission
ETA
= Throttle unit
Group 59
= Brake system
EXT. X
= Extended X-feed
Group 64
= Steering
GDL
= Gas discharge lamp
Group 83
= Doors and openings
HISPEED
= High speed data bus
Group 84
= Exterior decorative elements, etc.
IR
= Infrared sensor
Group 85
= Interior equipment
LIN
= LIN communication
Group 87
= Climate control system
LHD
= Left-hand drive
Group 88
= Internal equipment
LOSPEED
= Low speed data bus
MAN
= Manual transmission
Designations ignition switch
X
MEMORY
= Memory driver’s seat
MMS
= Mass Movement Sensor
= Accessories (audio position)
PETROL
= Gasoline
S
= Powered upon insertion of key
RHD
= Right-hand drive
15
= Contact remains connected during
start
SCR
= Screened
SRS
= Airbag
15l
= Contact is broken while starting
T
= Turbocharged engine
30
= Constant power from the battery
W/O
= Without
50
= Start
2WD
= Two-wheel drive
4CYL, I4
= 4-cylinder engine
Countries/Markets
A
5CYL, I5
= 5-cylinder engine
= Austria
AUS
= Australia
Colors
BK, SB
B
= Belgium
= Black
CDN
= Canada
BN
= Brown
CH
= Switzerland
BU, BL
= Blue
D
= Germany
GN
= Green
DK
= Denmark
GY, GR
= Gray
E
= Spain
LGN
= Light Green
EU/OS
= Markets outside USA and Canada
OG, OR
= Orange
FIN
= Finland
PK, P
= Pink
GB
= Great Britain
RD, R
= Red
ISR
= Israel
VT, VO
= Violet
J
= Japan
WH, W
= White
KOR
= Korea
YE, Y
= Yellow
N
= Norway
NL
= Netherlands
S
= Sweden
USA
= United States of America
WEU
= Western Europe
TP 39167202 C30/S40 (04-)/V50/C70 (06-) 2010 Supplement
5
[ Pobierz całość w formacie PDF ]

Linki

: 2010.09 Szkoła konstruktorów klasa III, Elektronika, Szkoła konstruktorów, Szkola konstruktorow klasa III

: 2010 AON - Bibliografia publikacji pracowników w 2008r, 002-05 WOJSKO POLSKIE OD 01.01.1990, AON - Bibliografia publikacji pracowników